Technical Bulletin
Toluol (Toluene)
|
|
Technical Bulletin |
|
|
Toluol (Toluene) |
||
|
ALLPRO® Corporation |
AP7590 - 21084 |
| Description | A
specialty solvent primarily for thinning oil based paints when faster
than normal drying is desired. It is also used for cleanup of spray guns
and other application equipment. Do not over thin coatings. Overthinning
will cause paint to become brittle and appear flat.
|
| Prominent Features |
|
| Uses | Thins
specialty paint, lacquer and varnish. Removes grease and oil. Thins solvent
based paints where specified by the manufacturer. Use where maximum solvency
is required. Excellent cleanup for tools and equipment immediately after
use.
|
| Limitations | Do
not use as a general purpose cleaner. May soften or damage plastics, synthetics
and other finishes. Do not use on linoleum, rubber, asphalt tile and fiberglass.
Safety
Note: Paints thinned with Toluol give off
higher than usual quantities of flammable vapor during drying. When
coating larger areas, be aware of the increased fire hazard. If ventilation
equipment is used, it must be explosion proof. If Toluol is used for
any other purpose, limit flammable vapors by using only a few ounces
at a time. Wait until all vapors are gone between uses. Read all cautions
on label prior to using. |
| Disposal | Contains
organic solvents which may cause adverse effects to the environment if
disposed of improperly. Place empty containers in normal refuse
for disposal. Contact your local sanitation department or household hazardous
waste coordinator for information concerning possible reuse or disposal
of unused solvent-containing products.
|
|
Caution |
Technical Information |
| DANGER!
HARMFUL OR FATAL IF SWALLOWED. FLAMMABLE LIQUID & VAPOR. VAPOR HARMFUL.
VAPORS MAY CAUSE FLASH FIRE. CONTAINS TOLUENE. Keep away from heat, sparks
and flame. Vapors are given off rapidly during use and may ignite explosively.
Vapors are heavier than air and may travel long distances to other rooms
or lower areas. DO NOT use in confined areas such as basements or bathrooms.
Open all doors and windows to provide plenty of fresh air cross ventilation
equal to outdoor conditions. DO NOT smoke. Extinguish all flames and pilot
lights, and turn off stoves, heaters, electric motors and other sources
of ignition during use and until all vapors are gone. Vapors may linger
for 30 minutes or more after use. If you smell Toluol, vapors are still
present. Do not turn ignition sources on or relight pilot lights until
certain that all vapors are gone. Avoid rubbing; friction may cause static
electric sparks which may ignite vapors. Do not attempt to start or re-ignite
charcoal, wood or any other fire with this product. An explosive fire
may result or fire may flash back into the can and explode. For disposal
guidance of unused product, contact a household hazardous waste program,
or your local or state government environmental control agency. Health Hazards: Vapor Harmful. May affect the brain or nervous system causing dizziness, headache or nausea. Causes eye, skin, nose and throat irritation. Avoid breathing vapor or spray mist. If you experience eye watering, headaches, dizziness or have difficulty breathing, increase fresh air or wear respiratory protection (NIOSH/MSHA TC 23C or equivalent) or leave the area to obtain fresh air. Reports have associated repeated and prolonged occupational overexposure to solvents with permanent brain and nervous system damage. Intentional misuse by deliberately concentrating and inhaling contents may be harmful or fatal. WARNING: THIS PRODUCT CONTAINS CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER, AND BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM. FIRST AID - IF SWALLOWED, do not induce vomiting. CALL PHYSICIAN IMMEDIATELY. In case of eye contact, flush thoroughly with water and get medical attention; for skin contact, wash thoroughly and get medical attention if irritation persists. If overcome by vapors, remove to fresh air and get medical attention. KEEP OUT OF REACH OF CHILDREN. Manufactured For: |
Packaging:
'F' style metal container 4 gallons per case Weight Per Gallon: 7.25 lbs./gal. Boiling Point: 230º - 233º F Vapor Density: Heavier than air % Solids By Weight: 0% % Solids By Volume: 0% Photochemical Reaction: Photochemically reactive Flash Point: 40º F CPSC Flamm. Class.: Flammable Storage: Keep container tightly closed when not in use. Store in a cool, dry place. Do not store near flames or at elevated temperatures. MAX Vapor Pressure: 22 mm Hg at 20º C Air Quality Data: MAX VOC 862 g/l Analysis CAS Toluene (108-88-3)
|